Revolutionary turfgrass growing environment hits the market.
ORLANDO, February 18 2020: Moisture control specialist Capillary Concrete has announced that its revolutionary new Capillary Hydroponics turfgrass growing environment is now on sale.
The system uses the capillary properties of Capillary Concrete to enable both drainage and irrigation from below and to precisely regulate the moisture content of the turf’s rootzone.
Martin Sternberg, Capillary Concrete inventor and CEO, said: “The system divides the turf into two areas of equal size. A control basin automatically oxygenates and pumps or drains water between the two areas on a regular schedule. The system is powered by a small solar panel and the water levels in the turf profile can easily be adjusted.”
Capillary Hydroponics enables massive increases in gas exchange below the top four inches of the rootzone – the area which conventional aeration methods do not adequately service. Because carbon dioxide molecules are heavier than those of oxygen this root-damaging gas is hard to remove from deep in a profile but, the system pushes out the heavier molecules and sucks oxygen into the turf profile by raising and lowering the water table. It also delivers optimal levels of nutrients directly to the rootzone.
Capillary Hydroponics has been in use for over a year in a number of trial sites. At Pompano Beach GC in Florida, a test green has been in place for just over a year. Scott Zakany CGCS, president of Cypress Golf Management, which runs the course, said: “The results on our test green are truly astounding. Since we installed this test green, we have seen a huge increase in our roots and huge decrease in our water usage, because the green is completely irrigated and fertilised from below ground, which means we don’t lose water to evaporation and we don’t have to spray fertilisers all the time. This product is going to revolutionise the way we manage and maintain our courses!”
In September/October 2018 Capillary Concrete built a new tee box at Hawk’s Landing GC outside Orlando incorporating the Capillary Hydroponics system, along with superintendent Josh Kelley’s team and contractor Double Eagle Golf Works. The system divides the tee box into two areas, with a layer of Capillary Concrete under the rootzone. Two air lift pumps, powered by a 55 watt solar panel, move water inside the closed system.
“It is a trial site; we aren’t doing anything special to it,” Kelley said. “We have run no overhead irrigation at all, except to water in two applications of herbicide. The tee itself has performed superbly; zero hotspots, no disease issues, no wet areas.”
Martin Sternberg said: “After almost a year, we can say that it has used 65 per cent less water than a similar sized, conventionally irrigated tee box, and we think that we can tweak the system to get that figure to 85 per cent. I started experimenting with tees five years ago in Sweden, primarily as a subsurface irrigation project. But the addition of a hydroponic moving water table – which we can do because of the strength and capillary properties of our product – is what makes this a game changer. We know we are getting up to 6,000 per cent more gas exchange in the rootzone in comparison to convention methods of aeration, and it is obvious that will have a massive impact on turf health. This is akin to what happens naturally in a seaside links environment, where you typically have a very low water table – but critically, it moves with the tide. That promotes a gas exchange. The best way to promote gas exchange is to push it with a water front – which is what we can do using Capillary Concrete. The hydroponic industry is 25-30 years ahead of us in the turfgrass industry in terms of understanding how to optimise plant root oxygen exchange, but it hasn’t been physically possible to build large outdoor structures for hydroponics without a product that performs as Capillary Concrete does. If you compare the cost of building, to use Capillary Hydronponics is slightly more expensive than building a push-up or California tee, but comparable to USGA specification construction.”
Josh Kelley says: “I really think in markets where water is scarce or expensive, this will change the way we do things in the golf business, and I’m delighted that we at Hawk’s Landing were one of the first to get to try it out.”
For more on Capillary Hydroponics, contact your local Capillary Concrete representative, or visit www.capillarybunkers.com.
NOTES TO EDITORS
1. Capillary Concrete is a patented sports-base drainage and sub-surface irrigation material. It is strong, environmentally sound and easy to mix and install. It has the ability to drain enormous amounts of water and store them for a slow and later release, still keeping a minimum level of moisture by the scientific principle of capillary action, which is the ability of a liquid to flow in narrow spaces, in opposition to the gravitational force. Capillary Concrete is the only sports base material that can remove water and replenish moisture at the same time, essential in presenting the best sports surfaces, park turf areas, equestrian sports fields, volleyball courts, etc.
2. Capillary Concrete was developed by Martin Sternberg, a Swedish golf professional, course superintendent and entrepreneur. The product has been installed on over 400 golf courses around the world. For more information visit http://www.capillarybunkers.com
3. Photography to support this release can be downloaded from: https://www.dropbox.com/sh/6avceugwul9k18a/AAAjRC8zEpbv5-giJYJHDMkLa?
Issued by Adam Lawrence, Oxford Golf Consulting
firstname.lastname@example.org, tel +44 (0)7971 754649.